Roadtrip to the Races, Part I

We made it!  We drove that old truck 'n' trailer all the way to the Bonneville Salt Flats and back!  Now for those of you who haven't sat through our longwinded tale of the trip, settle in for some reading.

2:30pm on August 11, our travel group gathered (after waiting approx. 6.5 hours for the last members of the party) to hit the road south to the Nampa area.  The trailers were all being pulled for the first time by these owners, and our truck and Marc's car were only minimally tested for roadworthiness.  For this reason, the late start had us a bit uptight.  As we slowly climbed the first hill and watched the temperature gauge needle rapidly climbing, panic set in.  We lost power toward the top and Andy thought for sure the motor was seizing.  We pulled over the first chance we got and everyone gathered 'round to look for the source of the problem.  Bad thermostat? bad gauge? bad radiator? so many possibilities...

While the brainstorming was going on, I watched the temp needle continue to climb until it pegged past all markings and numbers.  If the gauge wasn't bad before, it certainly was now!  Having no other way to measure temperature, we turned back home for the infrared thermometer.  Everything checked out warm, but not scary-hot there, so we packed the thermometer with us and up the hill we went again, pulling off to take  some thermo readings at the top.  Everything under the hood was uncomfortably hot, so we called the local parts stores to locate a new radiator and all the possibilities were discussed again.  Eventually, the guys discovered an air bubble in the top radiator hose that was preventing the cooled fluid from circulating.  That was an easy fix and off we went again - stopping in Moscow to pick up the new radiator for just-in-case and to install a new temp. gauge for the long, hilly road ahead.  Finally, at 4:30pm, we were on our way again.  We braced for every hill, but made it through Lewiston and Lapwai without another problem.  Then, as we climbed the Winchester Grade, our engine started cutting out.  We pulled over just short of the top, and came to the conclusion that we had run out of gas!  We hadn't tugged the trailer behind before, and our roadside calculations put us at 5mpg.  This was going to be a rather expensive trip!

We were carrying spare gas with us, so dumped that in and continued on.  But...at the top of the hill, the engine was starving for fuel again!  Now what?  We topped off at the gas station there, noticing that the 20-gallon tank was only 6 gallons low, and the guys fiddled with the carburetor to see if that might be the problem instead.  Away we went again, had no problems, and arrived at our destination for the night just before 1am...exhausted and relieved.  Our host had planned a surprise welcome party for us (expecting us around 8pm), but only a few stragglers remained to greet the tardy travelers.  They all had numbers written on their palms, which turned out to be their bet for our time of arrival.  Quite the people who would make the most of waiting 5 hours!  We all slept in our trailers for the first time that night - it was comfy.

Andy and I woke early to a very quiet yard.  Nobody else was stirring except the fellow who lived there.  We couldn't sleep anymore, so we wandered about the place, fixed a few things on the trailer, met the other hotrodders who were joining our caravan as they arrived, and finally woke the rest of our party up to finish this roadtrip to Bonneville.

We made it just south of Boise before stopping for a couple of hours so the ill-prepared of our group could grocery shop for the week.  We turned it into a lunch break for us, and got to know the other guys in the caravan better.  As we continued on, we noticed Marc's trailer was fishtailing horribly every time he went downhill , was passed by a truck, or drove too fast.  We alerted him over the 3-way radio, and he wasn't concerned.  We stopped for gas in one fo the small towns along Hwy 30 - it was a sight to see.  Too bad it wasn't a retro gas station!

Finally, while stopped there, we convinced Marc that his swaying trailer was serious enough to need fixed.  He found a hotrod shop / U-Haul store where they would fix his hitch, and the rest of us found some shade in a nearby park to pass the time.

And, the drive continued with no more dancing trailers!  We drove through the desert of Southern Idaho, with curiously green patches of irrigated fields...

...then, into the desert of Nevada, with.....umm....?

Of course it is on such an endless stretch of road that our hardworking engine can't find fuel again, and we found ourselves on the side of the road looking for solutions.  A very kind streetrodder stopped, and his ride drew a crowd.  It was beautifully done, and he was going to drive it down on the salt too!

Our problem turned out to be vapor lock - the gas was getting so hot that it turned to vapor in the lines and the carburetor apparently doesn't count that as adequate fuel to run the engine!  The temporary solution available in the middle of the Nevada desert was to remove the truck's hood to allow more airflow to cool the fuel lines.

We took the remainder of the hills very slowly, and were soooo excited to finally see the sign for Bonneville at dusk.

Once again, tired and relieved, we pulled into our 'campground'.  This time, instead of in a buddy's backyard, we claimed a little patch of the huge expanse of desolate land known as the Bend in the Road.

The adventure begins continues...

You, Me, and #3

In the time we've been together, Andy and I have worked to get 3 pretty cool old vehicles road-worthy.  Our first summer was spent making the Buick more reliable.  That kept us pretty entertained until the Dodge came along the summer before we were married. Once life settled down again, Andy worked to build that Dodge up from the ground to a head-turning hot rod.  Last Fall, plans of starting a hot rod business were forming and Andy was keeping his eye out for a shop truck.  And he found one!  The GMC belonged to a guy who was transferred for his job and did not want to move it with him, so it came home with us.  A week ago, we rolled project #3 out of the shop just after dark and went for a little joy ride, balancing precariously on upside-down 5-gallon buckets!

A few more evenings in the shop and driving it to work in the mornings, and August 4 was here.  After work, we planned to pack a picnic and head for the hills in our "new" ride.  We filled up with gas and hit the road for home.  Less than a mile from the gas station, we sputtered to a stop on the side of the road.  There's no way we could be out of gas, but it sure acted like it!  So we rested on the side of road and made a few phone calls to see if we could get help at the parts store after hours.  As luck would have it, somebody was still there and we were able to start the truck again and get it going downhill to the store.  A new fuel pump seemed to do the trick and we were on our way again with the sunlight fading fast.

We were still determined  to celebrate our 3 years of happily ever after with a backroads drive in the GMC, so we took off for the hills racing sunset.

We had a great time cruising the gravel roads in our old farm truck, spontaneously deciding which way to go at each fork in the road.

And the waning sunlight turned out to be perfect for a photo shoot!

 

We even got to see a mama moose and baby pretty close-up...nervously putting the truck in reverse at one point when it looked like she might run us down!

Looking forward to many more memorable anniversaries, and oodles of happy memories in between.

These Summer Evenings

We try to slow down a little and enjoy the time we have between working at the office(s) and working on the Bonneville projects each evening.  Oftentimes, we take dinner out to the back deck to watch all the little things going on in our part of the world.  Dinner and a show!

Andy's been smoking chicken and cheese in our hand-me-down Little Chief, and boy is it good!

 The clematis that climbs the shop has been in full bloom - the deep purple is stunning.

Actually having flowers in the flower pots makes me happy - it brings much more life to the deck.

The animals in the pasture bordering our backyard parade by every evening:

Quite possibly our favorite actors are the hummingbirds.  We have a great view of their feeder while we eat our own dinner.

 They are so fascinating to watch!  Four of these energetic little birds dance around our feeder and backyard all day.  We've figured out which one is the bully and which ones have learned to share...

 

 And, our favorite is this little one with the shiny teal color on its back.

Weekend evenings tend to be a little more relaxed.  Don and Faith often stop by for dinner and games.  Here, Andy is concentrating on skunking Don in cribbage.

Oh, the little things.

Crossing Off That List

Nope, this isn't the same post again.  Notice this truck looks a little more complete up front!

Andy's been going full speed ahead on the GMC.  We didn't get it on the road last weekend, but we're not giving up yet.  We did take one night off to watch The World's Fastest Indian.  Amazing story, and very motivational to our cause :)

Andy got the truck running a few nights ago, and he adjusted the timing yesterday so it runs like a champ.

Also yesterday, we made an attempt to bleed the brakes (let me tell you, pumping brakes while perched on uneven 4x4s is a tad tricky), and something just wasn't right.  Forrest came over and helped troubleshoot, and they determined that the master cylinder was bad.  So...off Andy went to the parts store right before closing to see if he could find a replacement.

Find one he did, and we successfully got all of the air out of the brake lines!

It was about 9:30pm by this time, but bedtime was not just around the corner.  The thought of only 2.5 weeks to get this thing road-ready and tested before Bonneville kept us going.

Andy worked on wiring.  He'd been working a little every day on everything under the dash, and the electric fan was done earlier in the day.

Next in line was wiring everything behind the cab.

He got the taillights done, and is out there working on the headlights right now.

While Andy was wiring the night away, I was working to clean up the cab interior and prep it for finish work.

Endless piles of rotten rubber and rusty dust, two disturbing discoveries of mice nests, and one horse-grooming brush later and this thing is clear of signs of its past as a farm truck and is ready for a makeover!

When we looked up from our work, it was nearly 2am!  Now that's a good shop night!

The trailer didn't get quite as much attention, but it's progressing as well.  Plus, I thought I'd share a few more Before pictures so I don't jump right to After pictures!  So, come on in...

 This will soon be the dining area:

The kitchenette (a.k.a. the workbench):

Sleeping corner (yes, we'll be adding a mattress to those wood slats):

And, look! curtains!

Faith did a fabulous job with these for the "bedroom".  I can't wait to see the rest!

Thanks for checking in.  I better get back out there!

At Long Last...A Projects Post!

To all who have been waiting to see...our summer builds are coming right along.

The '49 GMC has been up on jack stands for months on end.  Andy's tired of looking at it, and is trying his hardest to get it rolling and running by the end of today!

The motor's been cleaned up and has new belts and hoses to make sure it runs smoothly when he fires it up.

 

Ready for fuel with a gas tank in a slightly safer location than the original, which was right behind the seat in the cab!

Steering and brakes are ready - just have to bleed the brakes here soon.  Accelerator is hooked up as of yesterday.  Wiring is in progress, as you can see.  New window glass is here waiting to be installed (whoohoo for side windows in this truck!); all the old crispy door rubber is gone and the new stuff waiting to replace it; seat brackets are built, and this cab is about ready to insulate and finish up!

Speaking of brakes, here are snapshots of the front and rear set-ups:

 And suspension!  A must for a long roadtrip, pulling a load.  Andy's hooked up leaf springs, shocks, and air bags.  This should be a pretty nice ride.

 

 The leaf springs had to be mounted upside-down from the original Nova suspension, so Andy fabricated a bracket to let the ends pivot as needed.

Although shop nights with Forrest weren't as frequest with this build as with the Dodge, they still managed to get together occasionally and help with each others' projects.

Now that Andy's almost got the vehicle ready to go down the road, it's time to fix up our lodging for the trip.

Our lovely '53 trailer is finally getting some attention!  It's been airing out since the rain let up, and we replaced the broken glass and gave it new tires.  Neither Andy or I are qualified for the next part of the project...

 Finishing the inside of the trailer requires a lot of sewing! 

  As short as it is, the trailer has nine windows that all need curtains.  The curtains that came with it are a very faded red gingham.  We're transforming the interior into a 50s island getaway.  Faith came to the rescue and is sewing the new curtains as I type.

There is currently no place to sit or sleep in the trailer.  It was gutted, in the process of remodel, when I bought it, so we're working to create new furniture for it.  The foam is cut for the benches and odd-size bed (some variation of a 3/4 mattress), and we're hoping the upholstery part goes smoothly.

 There will be more to see before long!

I better get back to helping...